Particle emission rates during electrostatic spray deposition of TiO2 nanoparticle-based photoactive coating.

Here, we studied the particle release rate during Electrostatic spray deposition of anatase-(TiO2)-based photoactive coating onto tiles and wallpaper using a commercially available electrostatic spray device. Spraying was performed in a 20.3m3 test chamber while measuring concentrations of 5.6nm to 31µm-size particles and volatile organic compounds (VOC), as well as particle deposition onto room surfaces and on the spray gun user hand. The particle emission and deposition rates were quantified using aerosol mass balance modelling. The geometric mean particle number emission rate was 1.9×1010s-1 and the mean mass emission rate was 381µgs-1. The respirable mass emission-rate was 65% lower than observed for the entire measured size-range. The mass emission rates were linearly scalable (±ca. 20%) to the process duration. The particle deposition rates were up to 15h-1 for <1µm-size and the deposited particles consisted of mainly TiO2, TiO2 mixed with Cl and/or Ag, TiO2 particles coated with carbon, and Ag particles with size ranging from 60nm to ca. 5µm. As expected, no significant VOC emissions were observed as a result of spraying. Finally, we provide recommendations for exposure model parameterization.

Acute and subacute pulmonary toxicity and mortality in mice after intratracheal instillation of ZnO nanoparticles in three laboratories.

Inhalation is the main pathway of ZnO exposure in the occupational environment but only few studies have addressed toxic effects after pulmonary exposure to ZnO nanoparticles (NP). Here we present results from three studies of pulmonary exposure and toxicity of ZnO NP in mice. The studies were prematurely terminated because interim results unexpectedly showed severe pulmonary toxicity. High bolus doses of ZnO NP (25 up to 100 µg; ≥1.4 mg/kg) were clearly associated with a dose dependent mortality in the mice. Lower doses (≥6 µg; ≥0.3 mg/kg) elicited acute toxicity in terms of reduced weight gain, desquamation of epithelial cells with concomitantly increased barrier permeability of the alveolar/blood as well as DNA damage. Oxidative stress was shown via a strong increase in lipid peroxidation and reduced glutathione in the pulmonary tissue. Two months post-exposure revealed no obvious toxicity for 12.5 and 25 µg on a range of parameters. However, mice that survived a high dose (50 µg; 2.7 mg/kg) had an increased pulmonary collagen accumulation (fibrosis) at a similar level as a high bolus dose of crystalline silica. The recovery from these toxicological effects appeared dose-dependent. The results indicate that alveolar deposition of ZnO NP may cause significant adverse health effects.